Page 5 of 7
Re: Exhaust, rear diff swap, DOD delete, and LSA Supercharge
Posted: Sun Aug 06, 2017 6:30 pm
by loopy127
http://www.ebay.com/itm/Camaro-Longtube ... Kd&vxp=mtr
Here is the link. I have not fitted them yet to see if they'll work without massaging them, but they're going on my car one way or another.
Re: Exhaust, rear diff swap, DOD delete, and LSA Supercharge
Posted: Mon Aug 07, 2017 10:09 am
by kevink
Those headers actually don't look all that bad. They are much more equal length than my Kooks, which vary 10-12" between primaries. That is total BS in my opinion, especially since there is plenty of room to make them equal length. Hopefully they don't need too much modification to fit the Caprice.
Re: Exhaust, rear diff swap, DOD delete, and LSA Supercharge
Posted: Thu Aug 10, 2017 12:23 am
by loopy127
Re: Exhaust, rear diff swap, DOD delete, and LSA Supercharge
Posted: Thu Aug 10, 2017 12:38 am
by loopy127
The passenger side didn't pose quite so many issues, but I did end up fighting the transmission lines and the motor mount. I actually almost cut a section out (with the intent of re-welding) of the number two primary to accommodate the amount of space that was taken up by the transmission lines, which ran around the engine mount in the exact-wrong place. But I ended up using tie down straps to bend the lines out of the way, which meant that beating it with the hammer would clearance it enough to go around the motor mount.
- 20170809_161458.jpg (296.46 KiB) Viewed 14533 times
- 20170809_161447.jpg (273.77 KiB) Viewed 14533 times
I worked straight through until dark to get the car back together, so I didn't get any shots of the completed product. I'll be climbing back under the car tomorrow to weld up a couple of exhaust hangers and I'll get some shots of how it all turned out. I'm not sure what a kooks set of headers and cats would have cost, but I've got about $350 into the new headers and cats. I definitely ended up having to work for the money that I saved, but considering the fact that the difference between my setup and the kooks setup is roughly $1,000, I consider it time and money well spent. And if anyone thinks that I beat the crap out my headers, you're right. But I don't feel too bad about it after watching this...
https://www.youtube.com/watch?v=azPKIjxmmdU
Re: Exhaust, rear diff swap, DOD delete, and LSA Supercharge
Posted: Thu Aug 10, 2017 12:56 am
by s/c'd cav
ouch ! doesnt look like much fun
Re: Exhaust, rear diff swap, DOD delete, and LSA Supercharge
Posted: Thu Aug 10, 2017 10:47 am
by loopy127
What are you talking about? They fit perfect....after 15 test fits and a few severe beatings
Also, I forgot to mention that three of the O2 sensors fit perfectly, but the drivers side upstream sensor did have to be lengthened.
Re: Exhaust, rear diff swap, DOD delete, and LSA Supercharge
Posted: Thu Aug 10, 2017 10:49 am
by kevink
It looks like they hang down quite a bit lower than Kooks. Can you take a photo from the side of the car with the camera slightly below the bottom of the rocker?
Re: Exhaust, rear diff swap, DOD delete, and LSA Supercharge
Posted: Thu Aug 10, 2017 10:56 am
by loopy127
Yes, I'll post up some photos when I get out to weld up the last two exhaust hangers.
Re: Exhaust, rear diff swap, DOD delete, and LSA Supercharge
Posted: Thu Aug 10, 2017 11:24 am
by s/c'd cav
loopy127 wrote:What are you talking about? They fit perfect....after 15 test fits and a few severe beatings
Also, I forgot to mention that three of the O2 sensors fit perfectly, but the drivers side upstream sensor did have to be lengthened.
only severe beatings
they must fit like OJ's glove
the driver side front o2 is always the one that needs some length to it
Re: Exhaust, rear diff swap, DOD delete, and LSA Supercharge
Posted: Thu Aug 10, 2017 4:22 pm
by loopy127